Oxygen in β phase: Ti-6Al-4V-0.39O alloy at 1200 MPa

A team from the University of Science and Technology Beijing, together with colleagues from the University of Auckland, the University of Queensland and other institutes, reported a titanium alloy in which oxygen is deliberately placed in both coexisting phases. The work was published on 3 November 2026 in Nature Communications doi.org. The resulting α-β-O' alloy, Ti-6Al-4V-0.39O, shows an ultimate tensile strength of 1200 ± 30 MPa and a ductility of 23.5 ± 1.5% doi.org. Its strength-and-strain product is 28.2 GPa·% doi.org.

Oxygen in the β phase

Oxygen is traditionally detrimental to ductility in titanium alloys. Recent studies have treated it as a design tool for forming beneficial microstructures, but its role has mostly been limited to the α phase of dual-phase α-β alloys, according to the authors doi.org.

The team considered introducing sufficient oxygen into the β phase while both phases coexist. They report that strategic oxygen partitioning across α and β enables a substantial oxygen content in β doi.org. This triggers a β → O' phase transformation through atomic rearrangements doi.org.

Deformation mechanism

According to the authors, the O' phase acts as a precursor for a stress-induced martensitic transformation, O' → α", during deformation doi.org. This activates two mechanisms together: transformation-induced plasticity and twinning-induced plasticity doi.org. The authors link the combination of strength and ductility in the alloy to this synergy doi.org.

The study included synchrotron radiation X-ray diffraction measurements on the BL12SW beamline at the Shanghai Synchrotron Radiation Facility doi.org.

The authors describe the result as a general principle for strategically tuning oxygen in titanium alloy design doi.org. They also state that the work demonstrates potential for recycling oxygen-contaminated titanium waste doi.org.

Beijing team: oxygen in β phase gives Ti-6Al-4V-0.39O alloy 1200 MPa strength and 23.5% ductility

Oxygen in the β phase

Deformation mechanism

Sources · 1

Read also

Authigenic carbonate found in Japan Trench sediments below 7000 m; flux estimated at 28.6 Tg C per Myr